Investigation of Rare Earth Elements from Coal-Derived Minerals of Sawahlunto Formation and Leaching Behavior Under NaOH and HCl Washing Treatment

Arif Algifari, Fitri Nauli, Andri Van Deni, Siti Aisyah, Dwi Wulan Syakira

Abstract


The growing demand for rare earth elements (REE) in modern technological applications has encouraged the exploration of alternative REE sources, including minerals associated with coal. This study aims to evaluate the potential of minerals in the Sawahlunto Formation coal from the Ombilin Basin as a secondary REE source through an alkaline leaching approach. Coal samples from the Sawahlunto Formation were subjected to alkaline leaching using sodium hydroxide solutions of 200–600 g/L at temperatures of 38–78 °C for 0.5–1.5 hours, followed by an acid-washing stage using 14% hydrochloric acid. X-ray fluorescence analysis identified yttrium, lanthanum, and cesium, with a total initial REE content of approximately 181 ppm. The leaching results show that under optimal conditions 400 g/L NaOH, 78 °C, and a particle size of 60/70 mesh, the residual REE content decreased to 2 ppm, indicating effective dissolution of REE-bearing mineral components. Subsequent acid washing further enhanced REE recovery by removing remaining soluble phases. These results demonstrate that coal from the Sawahlunto Formation possesses promising characteristics as a secondary REE source.


Keywords


REE; Sawahlunto Formation; Coal Minerals; Alkaline Leaching.

Full Text:

PDF

References


Agus, A., & Anggara, F. (2022). Petrological , mineralogical , and geochemical compositions of coal in the Ombilin Basin , West Sumatra , Indonesia. 262(2).

Al-Jaroudi, S. S., Ul-Hamid, A., Mohammed, A. R. I., & Saner, S. (2007). Use of X-ray powder diffraction for quantitative analysis of carbonate rock reservoir samples. Powder Technology, 175(3), 115–121. https://doi.org/10.1016/j.powtec.2007.01.013

Algifari, A., Makertihartha, I. G. B. N., Subagjo, S., & Prabowo, H. (2025). Y Zeolite-Based Catalyst for Palm Oil Cracking to Produce Gasoline. Bulletin of Chemical Reaction Engineering and Catalysis, 20(1), 129–142. https://doi.org/10.9767/bcrec.20267

Algifari, A., Yanti, S. R., & Nauli, F. (2023). Studi Review : Evaluasi Batubara Formasi Sawahlunto sebagai Batuan Induk Hidrokarbon. JUSTEK : JURNAL SAINS DAN TEKNOLOGI, 6(3), 308–322. https://doi.org/https://doi.org/10.31764/justek.vXiY.ZZZ

Aulia Agus Patria and Ferian Anggara. (2022). Microfacies and Depositional Environment of the Eocene Sawahlunto Coal, Ombilin Basin, Indonesia Aulia. Iraqi Geological Journal, 55(2022), 128–146. https://doi.org/10.46717/igj.55.1E.11Ms-2022-05-27

Belkin, H. E., Tewalt, S. J., Hower, J. C., Stucker, J. D., & O’Keefe, J. M. K. (2009). Geochemistry and petrology of selected coal samples from Sumatra, Kalimantan, Sulawesi, and Papua, Indonesia. International Journal of Coal Geology, 77(3–4), 260–268. https://doi.org/10.1016/j.coal.2008.08.001

Cao, S., Zhou, C., Pan, J., Liu, C., Tang, M., Ji, W., Hu, T., & Zhang, N. (2018). Study on Influence Factors of Leaching of Rare Earth Elements from Coal Fly Ash. Energy and Fuels, 32(7), 8000–8005. https://doi.org/10.1021/acs.energyfuels.8b01316

Koesoemadinata, R. P. (1981). Stratigraphy and sedimentation: Ombilin Basin, Central Sumatra (West Sumatra Province). PROCEEDINGS INDONESIAN PETROLEUM ASSOCIATION Tenth Annual Convention, May 1981 STRATIGRAPHY, January 1981, 217–249. https://doi.org/10.29118/ipa.343.217.249

Li, M., Li, J., Zhang, D., Gao, K., Wang, H., Xu, W., Geng, J., Zhang, X., & Ma, X. (2020). Decomposition of mixed rare earth concentrate by NaOH roasting and kinetics of hydrochloric acid leaching process. Journal of Rare Earths, 38(9), 1019–1029. https://doi.org/10.1016/j.jre.2019.06.012

Li, X., Jin, Z., Bai, G., Wang, J., & Linghu, J. (2020). Experimental study of the influence of water on spontaneous combustion of coal containing pyrite. International Journal of Coal Preparation and Utilization, 00(00), 1–16. https://doi.org/10.1080/19392699.2020.1713766

Li, Y., Hou, D., Ding, X., Kang, X., & Liu, Q. (2023). Influence of coal-measure kaolinite with different types on the preparation of kaolinite nanotube. Applied Clay Science, 246(November). https://doi.org/10.1016/j.clay.2023.107179

Martínez, C., Vidal-Moya, A., Yilmaz, B., Kelkar, C. P., & Corma, A. (2023). Minimizing rare earth content of FCC catalysts: Understanding the fundamentals on combined P-La stabilization. Catalysis Today, 418(March 2023), 114123. https://doi.org/10.1016/j.cattod.2023.114123

Modiga, A., Eterigho-Ikelegbe, O., & Bada, S. (2024). Extractability and mineralogical evaluation of rare earth elements from Waterberg Coalfield run-of-mine and discard coal. International Journal of Coal Science and Technology, 11(1), 1–12. https://doi.org/10.1007/s40789-024-00702-z

Mousavi, S. J. (2025). The recovery of rare earth elements and titanium using direct atmospheric leaching and digestion methods from low-grade monazite sources. 2, 151–156. https://doi.org/10.22059/IJMGE.2025.395838.595263

Patria, A. A., & Anggara, F. (2021). A Preliminary Economic Evaluation of Rare Earth Element and Yttrium (REY) in Indonesian Coal: Progress and Future Prospect. Indonesian Journal of Economic Geology, 1(1), 19–22. https://doi.org/10.51835/ijeg.2021.1.1.339

Patria, A. A., & Anggara, F. (2022). Petrological, mineralogical, and geochemical compositions of coal in the Ombilin Basin, West Sumatra, Indonesia. International Journal of Coal Geology, 262(2). https://doi.org/10.1016/j.coal.2022.104099

Prasodjo, H. (2024). Kepentingan Strategis Tiongkok dalam Penguasaan Pasokan dan Produksi. MANDALA Jurnal Hubungan Internasional, 7(2), 62–89.

Ruan, Z., Li, M., Gao, K., Zhang, D., Huang, L., Xu, W., & Liu, X. (2019). Effect of Particle Size Refinement on the Leaching Behavior of Mixed Rare-Earth Concentrate Using Hydrochloric Acid [Research-article]. ACS Omega, 4(6), 9813–9822. https://doi.org/10.1021/acsomega.9b01141

Sriramoju, S. K., Dash, P. S., & Majumdar, S. (2021). Extraction of clean coal from washery rejects and its effect on coking properties: an approach toward sustainable development. International Journal of Coal Preparation and Utilization, 00(00), 1–23. https://doi.org/10.1080/19392699.2021.1958795

Syamsur, I. G. D. (2023). Purifikasi Pregnant Leach Solution (PLS) Magnet Permanen (Ndfeb) Menjadi Serbuk Besi Dan Serbuk Logam Tanah Jarang. Politeknik Negeri Lampung.

Vansla, T., Aulia Rahman, H., & Har, R. (2023). Kajian Potensi Logam Tanah Jarang pada Batu Pasir Ombilin Atas dan Formasi Ombilin Bawah menggunakan Analisis X-Ray Fluorescence. Jurnal Bina Tambang, 8(2), 146–153.

Zonneveld, J. P., Zaim, Y., Rizal, Y., Ciochon, R. L., Bettis, E. A., Aswan, & Gunnell, G. F. (2012). Ichnological constraints on the depositional environment of the Sawahlunto Formation, Kandi, northwest Ombilin Basin, west Sumatra, Indonesia. Journal of Asian Earth Sciences, 45, 106–113. https://doi.org/10.1016/j.jseaes.2011.06.017




DOI: https://doi.org/10.31764/justek.v8i4.33908

Refbacks

  • There are currently no refbacks.


JUSTEK : Jurnal Sains dan Teknologi sudah terindeks

    

EDITORIAL OFFICE: