The exploration of indigenous plant-based coagulant for sumbawanese cheese production as probiotic source
Abstract
Sumbawa cow's milk processing is still limited even though it has the potential to be developed. Therefore, a diversification product like cheese as a source of probiotic is required. Cheese derived from milk that is coagulated using rennet which is expensive and has high halal critical point. Thus, an alternative coagulant that is affordable with low halal critical point such as local plant-based material is needed. This study used Sumbawa local cow’s milk to produce cheese which coagulated using pineapple and gooseberry and the addition of Lactobacillus lactis as the lactic acid bacteria. Observed parameters were clotting time, yield, hardness, protein, total fat, total lactic acid bacteria, and sensory quality. This experiment showed that the cheese yielded using pineapple was higher than that of gooseberry, while the cheese coagulated using gooseberry (26714 N/m2) was having firmer texture. Meanwhile, clotting time, protein content and total fat content of the cheese coagulated using both coagulants were the same. The total lactic acid bacteria of the cheese coagulated using pineapple and gooseberry was similar 10.80 Log CFU/mg and 10.84 Log CFU/mg, respectively. Sensory evaluation using quantitative descriptive analysis showed that the cheese coagulated using pineapple extract has higher aftertaste and bitter taste. Meanwhile, the cheese coagulated using gooseberry extract was dry, grainy, yellowish, and its overall acceptance was higher than that of pineapple.
Keywords
Full Text:
PDF (Bahasa Indonesia)References
Al-Mhmdy, S. M., & Al-Dulaimy, S. E. H. (2018). Performance Evaluation Of Drip Irrigation System According To The Suggested Standards. Iraqi Journal of Agricultural Sciences, 49(6), 1099–1109. https://doi.org/10.36103/ijas.v49i6.148
Anderson, R., Bayer, P. E., & Edwards, D. (2020). Climate change and the need for agricultural adaptation. Current Opinion in Plant Biology, 56, 197–202. https://doi.org/10.1016/j.pbi.2019.12.006
Apriyana, Y., & Kailaku, T. E. (2015). Variabilitas iklim dan dinamika waktu tanam padi di wilayah pola hujan monsunal dan equatorial. In Pros Sem Nas Masy Biodiv Indon (Vol. 1, pp. 366–372). https://doi.org/10.13057/psnmbi/m010233
Delgado-Ramírez, G., Bolaños-González, M. A., Quevedo-Nolasco, A., López-Pérez, A., & Estrada-Ávalos, J. (2023). Estimation of Reference Evapotranspiration in a Semi-Arid Region of Mexico. Sensors, 23(15). https://doi.org/10.3390/s23157007
Doorenbos, J., & Pruitt, W. O. (1977). Guidelines for predicting crop water requirements. FAO Irrigation and Drainage Paper, 24, 144.
Jaya, I. K. D., Sudika, I. W., Windarningsih, M., & Isnaini, M. (2021). Organic foliar fertilizer to improve yield of cayenne pepper (Capsicum frutescens L.) grown off-season. In E3S Web of Conferences (Vol. 306, p. 01016). EDP Sciences. https://doi.org/10.1051/E3SCONF/202130601016
Kasmin, H., Abd Razak, K. A., Buzaimi, A. S., Mohd Azman, H. N., Muhammad Suhaimi, A. F., Wan Mohamed, W. A., … Ahmad, N. A. (2022). Potential Alternative Evapotranspiration Estimation Methods for Batu Pahat Climatic Condition: A Quantitative Comparison. IOP Conference Series: Earth and Environmental Science, 1022(1), 1–9. https://doi.org/10.1088/1755-1315/1022/1/012078
Keller, J., & Karmeli, D. (1974). Trickle Irrigation Design Parameters. Transactions of the American Society of Agricultural Engineers, 17(4), 678–684. https://doi.org/10.13031/2013.36936
Kusmali, M., Munir, A., & Faridah, S. N. (2015). Aplikasi Irigasi Tetes Pada Tanaman Cabe Merah Di Kabupaten Enrekang. Jurnal AgriTechno, 8(2), 140–148.
Martins, D. S., Paredes, P., Raziei, T., Pires, C., Cadima, J., & Pereira, L. S. (2017). Assessing reference evapotranspiration estimation from reanalysis weather products. An application to the Iberian Peninsula. International Journal of Climatology, 37(5), 2378–2397. https://doi.org/10.1002/JOC.4852
Miranda, F. R., Gondim, R. S., & Costa, C. A. G. (2006). Evapotranspiration and crop coefficients for tabasco pepper (Capsicum frutescens L.). Agricultural Water Management, 82(1–2), 237–246. https://doi.org/10.1016/j.agwat.2005.07.024
Muanah, M., Karyanik, K., & Romansyah, E. (2020). RANCANG BANGUN DAN UJI KINERJA PENERAPAN TEKNIK IRIGASI TETES PADA LAHAN KERING. Jurnal Agrotek Ummat, 7(2), 103–109. Retrieved from http://journal.ummat.ac.id/index.php/agrotek/article/view/3128
Muhammad, M. K. I., Nashwan, M. S., Shahid, S., Ismail, T. bin, Song, Y. H., & Chung, E. S. (2019). Evaluation of empirical reference evapotranspiration models using compromise programming: A case study of Peninsular Malaysia. Sustainability (Switzerland), 11(16). https://doi.org/10.3390/su11164267
Nadia Umi, H., Agung Tricahya, R., Muhammad Farid, A., Radi, & Murtiningrum. (2020). Performance analysis of drip and sprinkler irrigation on pineapple cultivation. IOP Conference Series: Earth and Environmental Science, 451(1). https://doi.org/10.1088/1755-1315/451/1/012034
Ndiaye, P. M., Bodian, A., Diop, L., Deme, A., Dezetter, A., Djaman, K., & Ogilvie, A. (2020). Trend and sensitivity analysis of reference evapotranspiration in the Senegal River basin using NASA meteorological data. Water (Switzerland), 12(7). https://doi.org/10.3390/w12071957
Negm, A., Jabro, J., & Provenzano, G. (2017). Assessing the suitability of American National Aeronautics and Space Administration (NASA) agro-climatology archive to predict daily meteorological variables and reference evapotranspiration in Sicily, Italy. Agricultural and Forest Meteorology, 244–245(May), 111–121. https://doi.org/10.1016/j.agrformet.2017.05.022
Nugroho, A. A. S., Bowo, C., & Sudibya, J. (2019). Indeks Kekeringan Spi (Standardized Precipitation Index) Dan Pengaruhnya Terhadap Produktivitas Hortikultura Tahunan Di Kabupaten Jember. Berkala Ilmiah Pertanian, 2(4), 149. https://doi.org/10.19184/bip.v2i4.16312
Pérez-Urrestarazu, L., Egea, G., Franco-Salas, A., & Fernández-Cañero, R. (2014). Irrigation Systems Evaluation for Living Walls. Journal of Irrigation and Drainage Engineering-Asce, 140(4). https://doi.org/10.1061/(ASCE)IR.1943-4774.0000702
Priyonugroho, A. (2014). ANALISIS KEBUTUHAN AIR IRIGASI (STUDI KASUS PADA DAERAH IRIGASI SUNGAI AIR KEBAN DAERAH KABUPATEN EMPAT LAWANG). Jurnal Teknik Sipil Dan Lingkungan, 2(3), 457–470.
Purnadurga, G., Kumar, T. V. L., Rao, K. K., Barbosa, H., & Mall, R. K. (2019). Evaluation of evapotranspiration estimates from observed and reanalysis data sets over Indian region. International Journal of Climatology, 39(15), 5791–5800. https://doi.org/10.1002/JOC.6189
Ritung, S., Suryani, E., Subardja, D., Sukarman, Nugroho, K., Suparto, … Supriatna, W. (2015). Luas Penyebaran, dan Potensi Ketersediaan. Sumberdaya Lahan Pertanian Indonesia (2015th ed.). Jakarta: IAARD Press.
RIzal, M., Munir, A., & Prawitosari, T. (2012). RANCANGBANGUN DAN UJI KINERJA SISTEM KONTROL IRIGASI TETES PADA TANAMAN STRAWBERRY (Fragaria vesca L.). AgriTechno, 6(2), 68. Retrieved from https://scholar.google.co.id/citations?view_op=view_citation&hl=id&user=kUQa1QwAAAAJ&citation_for_view=kUQa1QwAAAAJ:iWL_APfBKHwC
Saidah, H, Yasan Wayan, H. E. (2014). Keseragaman Tetesan Pada Irigasi Tetes Siste M Gravitasi. Spektrum Sipil, Vol 1, No(2), 133–139.
Srivastava, P. K., Singh, P., Mall, R. K., Pradhan, R. K., Bray, M., & Gupta, A. (2020). Performance assessment of evapotranspiration estimated from different data sources over agricultural landscape in Northern India. Theoretical and Applied Climatology, 140(1–2), 145–156. https://doi.org/10.1007/s00704-019-03076-4
Sumarna, A. (1998). Irigasi Tetes Pada Budidaya Cabai. Irigasi Tetes Pada Budidaya Cabai. Bandung: Balai Penelitian Tanaman Sayuran.
Supriadi, D., Susila, A., & Sulistyono, E. (2018). Crop Water Requirement Determination of Red Pepper (Capsicum annuum L.) and Cayenne Pepper (Capsicum frutescens L.). Jurnal Hortikultura Indonesia, 9(1), 38–46.
Surmaini, E., Runtunuwu, E., & Las, I. (2011). Agriculturals Effort to Anticipate Climate Change. Jurnal Litbang Pertanian, 30(1), 1–7. Retrieved from http://www.ejurnal.litbang.pertanian.go.id/index.php/jppp/article/view/2480
Taghvaeian, S. (2014). Drip Irrigation Systems. Oklahoma Cooperative Extennsion Service.
Udiana, I. M., Bunganaen, Wi., & Padja, R. A. P. (2014). Perencanaan SIstem Irigasi Tetes (Drip Irrigation) Di Desa Besmarak Kabupaten Kupang. Teknik Sipil, III(1), 63–74. Adriane, F. Y., & Wikandari, P. R. (2021). Pengaruh Konsentrasi Lactobacillus plantarum B1765 terhadap Mutu Produk Keju Analog Kacang Kecipir ( Psophocarpus tetragonolobus ). Prosiding Seminar Nasional Kimia (SNK), 34–45.
Aini, N., Sustriawan, B., Prihananto, V., & Heryanti, T. (2019). Characteristics of cheese analogue from corn extract added by papain and pineapple extract. IOP Conference Series: Earth and Environmental Science, 255(1). https://doi.org/10.1088/1755-1315/255/1/012016
Akmal, H. M., Sumarmono, J., & Setyawardani, T. (2022). Pengaruh Penambahan Bubuk Daun Salam (Syzygium polyanthum) dengan Persentase yang Berbeda terhadap Persentase Produk, Warna, dan Total Asam Laktat Keju Susu Rendah Lemak. Bulletin of Applied Animal Research, 4(2), 58–64. https://doi.org/10.36423/baar.v4i2.1021
Albillos, A., de Gottardi, A., & Rescigno, M. (2020). The gut-liver axis in liver disease: Pathophysiological basis for therapy. Journal of Hepatology, 72(3), 558–577. https://doi.org/10.1016/j.jhep.2019.10.003
Ardiana, C., & Hernawati, D. (2019). Pengaruh Konsentrasi Ekstrak Buah Ceremai (Phyllanthus Acidus) terhadap Penggumpalan Susu Sapi Jenis FH (FRIESH HOLLAND) dalam Pembuatan Keju. Jurnal Life Science: Jurnal Pendidikan Dan Ilmu Pengetahuan Alam, 1(1), 1–10. https://doi.org/10.31980/jls.v1i1.616
Arifiansyah, M., Wulandari, E., & Chairunnisa, H. (2014). Karakteristik kimia (Kadar air dan protein) dan nilai kesukaan keju segar dengan penggunaan koagulan jus jeruk nipis, jeruk lemon, dan asam sitrat. Students E-Journal, 4(1), 1–14. http://jurnal.unpad.ac.id/ejournal/article/view/5816
Beltrán-Espinoza, J. A., Domínguez-Lujan, B., Gutiérrez-Méndez, N., Chávez-Garay, D. R., Nájera-Domínguez, C., & Leal-Ramos, M. Y. (2021). The impact of chymosin and plant-derived proteases on the acid-induced gelation of milk. International Journal of Dairy Technology, 74(2), 297–306. https://doi.org/10.1111/1471-0307.12760
BPS. (2023). sumbawa dalam angka 2023.
Coelho, M. C., Malcata, F. X., & Silva, C. C. G. (2022). Lactic Acid Bacteria in Raw-Milk Cheeses: From Starter Cultures to Probiotic Functions. In Foods (Vol. 11, Issue 15). https://doi.org/10.3390/foods11152276
Daulima, D. T., Andriyani, A., Mustofa, P. N., & Liputo, S. A. (2021). Cheese Analog Basis Susu Jagung Manis dan Susu Kedelai Sebagai Keju Rendah Lemak. Journal of Agritechnology and Food Processing, 1(2), 61. https://doi.org/10.31764/jafp.v1i2.6684
Enaud, R., Prevel, R., Ciarlo, E., Beaufils, F., Wieërs, G., Guery, B., & Delhaes, L. (2020). The Gut-Lung Axis in Health and Respiratory Diseases: A Place for Inter-Organ and Inter-Kingdom Crosstalks. Frontiers in Cellular and Infection Microbiology, 10(February), 1–11. https://doi.org/10.3389/fcimb.2020.00009
Fathiaturrahma, N., Kusdianawati, & Suharli, L. (2022). Dangke Hasil Olahan dari Susu Kuda Liar Sumbawa , Susu Sapi Sumbawa , dan Susu Kerbau Sumbawa. ANOA: Journal of Animal Husbandry, 1(2), 88–97.
Ghaisas, S., Maher, J., & Kanthasamy, A. (2016). Gut microbiome in health and disease: Linking the microbiome-gut-brain axis and environmental factors in the pathogenesis of systemic and neurodegenerative diseases. In Pharmacology and Therapeutics (Vol. 158, pp. 52–62). https://doi.org/10.1016/j.pharmthera.2015.11.012
Guna, F. P. G., Bintoro, V. P., & Hintono, A. (2020). Pengaruh Penambahan Tepung Porang sebagai Penstabil terhadap Daya Oles, Kadar Air, Tekstur, dan Viskositas Cream Cheese. Jurnal Teknologi Pangan, 4(2), 88–92. www.ejournal-s1.undip.ac.id/index.php/tekpangan.
Hunaefi, D., & Ulfah, F. (2019). Pendugaan Umur Simpan Produk Pastry dengan Quantitative Descriptive Analysis (QDA) dan Metode Arrhenius. Jurnal Mutu Pangan: Indonesian Journal of Food Quality, 6(2), 72–78. https://doi.org/10.29244/jmpi.2019.6.72
Jumiono, A., Mardiah, Amalia, L., & Puspasari, E. (2023). IDENTIFIKASI TITIK KRITIS KEHALALAN BAHAN NABATI DAN PRODUK TURUNAN BAHAN NABATI. Jurnal Ilmiah Pangan Halal Volume, 5(April), 21–29.
Kartawiria, I. S., Elvina, B., & Gunawan-Puteri, M. D. P. T. (2019). Milk curd properties attributed to the application of a pineapple juice as a coagulant in cheese production. Journal of Chemical Technology and Metallurgy, 54(4), 695–701.
Komansilan, S., Rosyidi, D., Radiati, L. E., & Purwadi, P. (2019). Pengaruh variasi pH dengan penambahan enzim bromelin alami (Anannas comucus) terhadap sifat organoleptik keju cottage. Jurnal Sains Peternakan, 7(1), 54–61. https://doi.org/10.21067/jsp.v7i1.3613
Luminturahardjo, W. (2021). Peranan Probiotik dalam Penanganan Infeksi COVID-19. Cermin Dunia Kedokteran, 48(5), 273. https://doi.org/10.55175/cdk.v48i5.1371
Mufidah, I., Hidayat, K., & Maflahah, I. (2023). Analisis Titik Kritis Keharaman Proses Produksi Keju Mozzarella Di Cv Abc. Prosiding Konferensi Integrasi Interkoneksi Islam Dan Sains, 5(2013), 69–74.
Mulyani, L. S., Ardiana, C., Kurniasih, N., Hernawati, D., & Rohayat, A. (2019). The effect of concentration of Ceremai (Phyllanthus Acidus) Fruit extract on FH (Friesh Holland) cattle milk clumping in cheese making. Journal of Physics: Conference Series, 1402(5). https://doi.org/10.1088/1742-6596/1402/5/055018
Nalley, W. M., Hine, T. M., & Kune, P. (2021). Penyuntikan Tiga Kali Ekstrak Pituitari Selama Induk Sapi Bali Bunting Meningkatkan Bobot Lahir dan Produksi Air Susu. Jurnal Veteriner, 22(2), 271–277. https://doi.org/10.19087/jveteriner.2021.22.2.271
Nugroho, P., Dwiloka, B., & Rizqiati, H. (2018). Rendemen, Nilai pH, Tekstur, dan Aktivitas Antioksidan Keju Segar dengan Bahan Pengasam Ekstrak Bunga Rosella Ungu (Hibiscus sabdariffa L.). Jurnal Teknologi Pangan, 2(1), 33–39.
Nurgrahadi, Puspawati, N. N., & Sugitha, I. M. (2020). Pengaruh Perlakuan 3 Jenis Bakteri Asam Laktat Dan Kombinasinya Terhadap Karakteristik Keju Kedelai. Jurnal Ilmu Dan Teknologi Pangan (ITEPA), 9(4), 412–425. https://doi.org/10.24843/itepa.2020.v09.i04.p06
Nurjanah, S., & Sari, R. N. (2023). PERSIAPAN PANELIS TERLATIH UNTUK ANALISIS PROFIL SENSORI SUSU RUMINANSIA SUMBAWA. UTS STUDENT CONFRENCE, 185–194.
Oštarić, F., Antunac, N., Cubric‐curik, V., Curik, I., Jurić, S., Kazazić, S., Kiš, M., Vinceković, M., Zdolec, N., Špoljarić, J., & Mikulec, N. (2022). Challenging Sustainable and Innovative Technologies in Cheese Production: A Review. Processes, 10(3). https://doi.org/10.3390/pr10030529
Silaban, I., & Rahmanisa, S. (2016). Pengaruh Enzim Bromelin Buah Nanas ( Ananas comosus L.) Terhadap Awal Kehamilan. Majority, 5(4), 80–85.
Stavropoulou, E., & Bezirtzoglou, E. (2020). Probiotics in Medicine: A Long Debate. Frontiers in Immunology, 11(September), 1–20. https://doi.org/10.3389/fimmu.2020.02192
Sukainah, A., Fadilah, R., Putra, R. P., & Akifah. (2021). Analysis Quality of Soft Cheese Cottage with Additional of Pineapple Juice (Ananas Comusus (L.) Merr) and Lactobacillus Fabifermentans. IOP Conference Series: Earth and Environmental Science, 709(1). https://doi.org/10.1088/1755-1315/709/1/012021
SURYANI, N. A. (2023). Kualitas Kimia Keju Susu Sapi Dengan Pemakaian Enzim Bromelin Dari Buah Nanas (Ananas comosus).
Syah, S. P., Sumantri, C., Arief, I. I., & Taufik, E. (2017). Karakteristik Minuman Whey Yang Difermentasikan Dengan Bakteri Asam Laktat Indigenus Asal Dangke. In Jurnal Teknologi dan Industri Pangan (Vol. 28, Issue 2, pp. 129–138). https://doi.org/10.6066/jtip.2017.28.2.129
Waqtarib, T. W., Sjah, T., & Sukardi, L. (2020). Analysis of the value added of milk candy agroindustry product in the northern moyo district sumbawa regency. Agroteksos, 30(2), 79–89.
DOI: https://doi.org/10.31764/jau.v10i4.19514
Refbacks
- There are currently no refbacks.
Copyright (c) 2023 Ariskanopitasari, Rizaldi, Sari
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
 |  |  |  |
| |||
 |  |  |
|
Alamat Kantor