ECO-INNOVATION SABUN KERTAS ANTISEPTIK HALAL BERBASIS POLYHERBAL DAN PEMANFAATAN LIMBAH CANGKANG TELUR AYAM

Annisa Kartika Sari; Etik Wahyuningsih; Nur Haliza Firdausi; Elok Siti Nurjannah; Laili Irfanah; Ria Hanistya

doi:10.31764/jmm.v10i4.39630

ECO-INNOVATION SABUN KERTAS ANTISEPTIK HALAL BERBASIS POLYHERBAL DAN PEMANFAATAN LIMBAH CANGKANG TELUR AYAM

Annisa Kartika Sari, Etik Wahyuningsih, Nur Haliza Firdausi, Elok Siti Nurjannah, Laili Irfanah, Ria Hanistya

Abstract

Abstrak: Permasalahan penumpukan sampah rumah tangga dan belum optimalnya pemanfaatan limbah cangkang telur ayam serta berbagai jenis tanaman herbal (polyherbal) terjadi di wilayah Rekesan, Provinsi Jawa Timur. Tujuan pengabdian ini adalah meningkatkan pengetahuan dan keterampilan masyarakat dalam mengolah limbah tersebut menjadi sabun kertas antiseptik halal bernilai ekonomi. Metode dilaksanakan melalui penyuluhan, demonstrasi, dan praktik langsung pada 28 anggota Perkumpulan Al-Hidayah Rekesan Prigen. Evaluasi dilakukan dengan memberikan 10 pertanyaan pre-test/post-test, dan uji hedonik. Hasil menunjukkan peningkatan pengetahuan signifikan, dengan persentase jawaban benar post-test mencapai 93–100% pada seluruh indikator, meningkat tajam dari 0–25% saat pre-test. Keterampilan peserta dalam melakukan formulasi sabun kertas terlihat dari produk akhir yang berhasil dibuat dan diterima dengan baik berdasarkan uji hedonik, dengan rata-rata skor pada kategori “suka” hingga “sangat suka”. Produk ini berpotensi membuka peluang usaha baru berbasis pemberdayaan masyarakat sekaligus mengurangi beban sampah lingkungan.

Abstract: The issues of household waste accumulation and the suboptimal utilization of chicken eggshell waste and various types of herbal plants (polyherbal) are prevalent in the Rekesan area, East Java Province. The objective of this community service project is to enhance the community’s knowledge and skills in processing these wastes into halal antiseptic paper soap with economic value. The methods employed included outreach sessions, demonstrations, and hands-on practice with 28 members of the Al-Hidayah Rekesan Prigen Association. Evaluation was conducted using a 10-question pre-test/post-test and a hedonic test. The results showed a significant increase in knowledge, with the percentage of correct answers on the post-test reaching 93–100% across all indicators—a sharp increase from 0–25% on the pre-test. Participants’ skills in formulating paper soap were evident in the final products they successfully produced, which were well-received based on the hedonic test, with average scores ranging from “like” to “love.” This product has the potential to open up new community-empowerment-based business opportunities while reducing the environmental burden of waste.

Keywords

Antiseptic Paper Soap; Eco-innovation; Eggshell Waste; Polyherbal.

Full Text:

DOWNLOAD [PDF]

References

Ahmed, T. A. E., Wu, L., Younes, M., & Hincke, M. (2021). Biotechnological Applications of Eggshell: Recent Advances. Frontiers in Bioengineering and Biotechnology, 9(July), 1–19. https://doi.org/10.3389/fbioe.2021.675364

Albitar, K., Nasrallah, N., Hussainey, K., & Wang, Y. (2024). Eco-innovation and corporate waste management: The moderating role of ESG performance. Review of Quantitative Finance and Accounting, 63(2), 781–805. https://doi.org/10.1007/s11156-024-01281-5

Ayodele, T. R., Alao, M. A., & Ogunjuyigbe, A. S. O. (2018). Recyclable resources from municipal solid waste: Assessment of its energy, economic and environmental benefits in Nigeria. Resources, Conservation and Recycling, 134, 165–173. https://doi.org/10.1016/J.RESCONREC.2018.03.017

Bustomi, M. Y. A., Maulina, N., Kinasih, L. S., & Arriziq, M. A. (2024). O-CITRI Soap: Antibacterial Paper Soap Made from Orange Peel (Citrus sinensis L.) and Basil (Ocimum sanctum L.). Indonesian Journal of Pharmaceutical Science and Technology, 11(2), 267–273.

Effendy, S., Neldi, V., & Ramadhani, P. (2024). Penetapan Kadar Flavonoid Total dan Fenol Total Serta Uji Aktivitas Antioksidan dari Ekstrak Etanol Bunga Rosella ( Hibiscus sabdariffa L .). 16(1), 71-79.

Ekawati, R., Ekawati, R., Partuti, T., Anggraeni, S. K., & Febianti, E. (2024). Pemanfaatan Limbah Organik Menjadi Bahan Bernilai Tambah Di Wilayah Serang Banten. Civil Engineering for Community Development (CECD), 3(2), 117–123. https://doi.org/10.62870/cecd.v3i2.32102

Fasihah, N. S., Maryani, Y., & Heriyanto, H. (2022). Pengolahan air limbah laundry menggunakan adsorbsi cangkang telur ayam. Jurnal Ilmiah Wahana Pendidikan, 8(20), 129–139.

Fitri, H. A., Wardani, G. K., Astuti, I. Y., & Hapsari, I. (2025). Optimasi Formula Ekstrak Bunga Rosela ( Hibiscus sabdariffa L .) sebagai Clay Facial Soap Formula Optimization of Roselle Flower Extract as Clay Facial Soap. Jurnal Riset Sains Dan Teknologi, 9(2), 333–344. https://doi.org/10.30595/jrst.v9i2.24495

Kaur, T., Juyal, A., & Rathore, H. (2024). The Circular Economy-Redefining Waste as a Valuable Resource. Just Agriculture, 4(6), 272–278. www.justagriculture.in

Kirchherr, J., Yang, N. H. N., Schulze-Spüntrup, F., Heerink, M. J., & Hartley, K. (2023). Conceptualizing the Circular Economy (Revisited): An Analysis of 221 Definitions. Resources, Conservation and Recycling, 194(September 2022), 107001. https://doi.org/10.1016/j.resconrec.2023.107001

Kusumanti, Y., Ilmawati, E. M., & Hasibuan, U. F. H. (2023). Uji Aktivitas Antioksidan Ekstrak Bunga Telang (Clitoria ternatea L.) Dengan Metode DPPH (2, 2 DIiphenyl 1-1 Pickrylhydrzyl). Journal of Pharmaceutical and Sciences,Vol 6 Issue 4, 1658–1664.

Langi, T. M., Koapaha, T., Lalujan, L., Studi, P., Pangan, T., & Pertanian, F. (2026). Pelatihan Pengolahan Minuman Fungsional Berbasis Bunga Telang Pada Kelompok Wanita Kaum Ibu GMIM Galilea Teling. Jurnal Pengabdian Masyarakat Bhinneka, 4(3), 2827–2833. https://doi.org/10.58266/JPMB.V4I3.874

Maksum, T. S., & Nurfadillah, A. R. (2024). Upaya Mewujudkan Desa Wisata Zero Waste melalui Pelatihan Pengelolaan Sampah Rumah Tangga di Kawasan Pesisir Bajo. Jurnal Pengabdian Masyarakat Farmasi : Pharmacare Society, 3(2), 39–47. https://doi.org/10.37905/PHAR.SOC.V3I2.26636

Namira, D. S., & Hendradi, E. (2023). Karakteristik Fisik dan Aktivitas Antibakteri Ekstrak Air Bunga Rosela (Hibiscus sabdariffa L) dalam Sediaan Gel Hydroxyethyl Cellulose (HEC). Camellia: Clinical, Pharmaceutical, Analytical and Pharmacy Community Journal, 2(1), 92–99.

Ooi, J. K., Woon, K. S., & Hashim, H. (2021). A multi-objective model to optimize country-scale municipal solid waste management with economic and environmental objectives: A case study in Malaysia. Journal of Cleaner Production, 316. https://doi.org/10.1016/J.JCLEPRO.2021.128366

Pratama, N. P., Rahayu, K., Sari, P., & Rahayu, B. (2024). Formulation of Antibacterial Liquid Soap Based on Butterfly Pea Flower ( Clitoria ternatea L .) Extract with Ultrasound-Assisted Extraction Technique. Journal of Biotechnology and Natural Science, 4(2), 62–69.

Ramdhini, R. N., & Dewi, S. S. (2024). Phytochemical Screening and Physical Evaluation of Liquid Soap Preparation with 96 % Ethanol Extract of Butterfly Flower ( Clitoria ternatea L .) Skrining Fitokimia dan Evaluasi Fisik Sediaan Sabun Cair Ekstrak Etanol 96 % Bunga Telang ( Clitoria ternatea. Indonesian Journal of Advanced Research (IJAR), 3(1), 105–118.

Sapanli, K., Sumberdaya, D. E., Lingkungan, D., Ekonomi, F., Manajemen, D., Bogor, P., Fikri, I., Dwi, A., Departemen, P., & Sumberdaya, E. (2023). Pengelolaan Sampah Rumah Tangga Berbasis Circular Economy di Tingkat Desa: Pendekatan Sistem Dinamik. Jurnal Wilayah Dan Lingkungan, 11(2), 141–155. https://doi.org/10.14710/JWL.11.2.141-155

Simbolon, P. S. M., & Siregar, R. M. (2025). Uji Aktivitas Antioksidan Ekstrak Kulit Jeruk Sunkist Muda Dan Tua Dengan Metode DPPH. HUMANITIS: Jurnal Homaniora, Sosial Dan Bisnis, 3(7), 204–212.

Solekah, N. A. A. R., Syafira, A. A., Mauludin, A. H., Inda, A. J., Afifah, B. S., Dariri, F., Faraz, L., Elfin, M., Hidayah, N. F., Soranda, R. F., & Rohmah, Y. (2024). Pengabungan Pemanfaatan Kelopak Bunga Rosella dan Susu Kambing dalam Pembuatan Sabun Padat di Dusun Rekesan Desa Sumberdem memiliki ciri khas biasa disebut kampung kambing merupakan tempat ternak kambing. JPKMI (Jurnal Pengabdian Kepada Masyarakat Indonesia), 5(2), 90–100.

Yuliasari, H., Ayuningtyas, L. P., & Erminawati, E. (2023). Identifikasi senyawa bioaktif dan evaluasi kapasitas antioksidan seduhan simplisia bunga telang (Clitoria ternatea L.). Jurnal Teknologi Pangan Dan Hasil Pertanian, 18(1), 1–9.

DOI: https://doi.org/10.31764/jmm.v10i4.39630